Dalton Junction rail crash
54°27′43″N 1°32′53″W / 54.462°N 1.548°W / 54.462; -1.548
A derailment of a night mail train from Scotland to London occurred on the North Eastern Railway when a tender axle suddenly fractured on 28 December 1869 near Dalton Junction, south of Darlington, England. There were only slight injuries among the staff, but the accident was a warning of the problem of premature axle failure.
Sequence of events
The train consisted of engine and tender, five carriages, two post office vans, and two brake vans. It left Darlington at 8.25 pm, and after about 4 miles (6.4 km), and moving at 40 miles per hour (64 km/h) towards Dalton Road bridge, the driver felt a sudden shock at the back of the engine. On looking around, he saw fire flying from the tender, and shut off the steam. The fireman could not apply the tender brake since the step to the brake had broken in the incident. The driver whistled for the guard's brakes, but did not reverse the engine for fear of damage to the carriages behind. The engine came to a dead stop in 220 yards from the point of alarm, and both guards and firemen went to the nearest stations to alert any oncoming trains of the blockage to the line. The engine was undamaged, but the tender had lost both leading wheels, axle and axle-boxes, although it was upright with the other four wheels intact, but off the rails. Most of the following vehicles were more or less damaged and off the track, damage being mainly confined to the wheel assemblies, but injuries were minimal, with only one passenger complaining. Six post-office clerks were "considerably shaken".[1]
Investigation
The tender axle was eventually found in four separate pieces, having fractured across the shaft, and the rails were severely damaged as well.
The axle was made of best Low Moor wrought iron, and had run about 220,000 miles (350,000 km) during its 7 years service (experience had shown that these axles could last up to 10 years or 300,000 miles (480,000 km)). The fracture surface of the principal break showed what is now called a slow growth region on the outer part of the diameter, with a fast growth section at the centre.[1] Although Captain Tyler of the Railway Inspectorate did not recognize the problem as fatigue, he had seen many similar fracture surfaces in his career and attributed the break to the two keyways machined into the outer surface of the axle. He was quite right. The fatigue cracks probably grew from one or more of the sharp corners of the keyways, extending slowly around the circumference until the axle could no longer support its load, and the crack (or cracks) grew catastrophically. The load on an axle is complex, but involves both bending from the load in the vehicle above, and torsion from the rotation of the axle. He suggested that three or four keyways rather than two be used, effectively spreading the load. Nowadays, the sharpness of the corners would also be reduced, thereby lessening the stress concentration. Axles with thicker shafts were produced after this accident, and their use would also have helped to lower net stresses in the axle.
See also
References
Peter R Lewis, Disaster on the Dee: Robert Stephenson's Nemesis of 1847, Tempus (2007).
- ^ a b H. W. Tyler (22 January 1870). "North Eastern Railway" (PDF). Accident Returns: 137–138.
- v
- t
- e
- Philadelphia (Jul 1815)
- Parkside (Sep 1830)
- Wetheral (Dec 1836)
- Harrow (Aug 1838)
- Howden (Aug 1840)
- Sonning Cutting (Dec 1841)
- Penistone (Oct 1845)
- Dee Bridge (May 1847)
- Sutton Tunnel (Apr 1851)
- Burnley (Jun 1852)
- Straffan (Oct 1853)
- Reading Southern (Sep 1855)
- Lewisham (Jun 1857)
- Round Oak (Aug 1858)
- Helmshore (Sep 1860)
- Atherstone (Nov 1860)
- Wootton (Jun 1861)
- Clayton Tunnel (Aug 1861) ‡
- Kentish Town (Sep 1861)
- Winchburgh (Oct 1862)
- Rednal (Jun 1865)
- Staplehurst (Jun 1865)
- Welwyn Tunnel (Jun 1866)
- Yanwath (Feb 1867)
- Warrington (Jun 1867)
- Abergele (Aug 1868) ‡
- Maesycwmmer (Jun 1869)
- Dalton Junction (Dec 1869)
- Newark (Jun 1870)
- Tamworth (Sep 1870)
- Stairfoot (Dec 1870)
- Hatfield (Dec 1870)
- Kirtlebridge (Oct 1872)
- Wigan (Aug 1873)
- Menheniot (Dec 1873)
- Bo'ness Junction (Jan 1874)
- Thorpe (Sep 1874) ‡
- Shipton-on-Cherwell (Dec 1874) ‡
- Kildwick & Crosshills (Aug 1875)
- Abbots Ripton (Jan 1876)
- Radstock (Aug 1876)
- Heeley (Nov 1876)
- Morpeth (Mar 1877)
- Tay Bridge (Dec 1879) ‡
- Burscough Junction (Jan 1880)
- Wennington Junction (Aug 1880)
- Inverythan (Nov 1882)
- Penistone (Jul 1884) ‡
- Penistone (Jan 1885)
- Hexthorpe (Sep 1887) ‡
- Penistone (Mar 1889)
- Armagh (Jun 1889) ‡
- Norton Fitzwarren (Nov 1890)
- Norwood Junction (May 1891)
- Esholt Junction (Jun 1892)
- Thirsk (Nov 1892)
- Llantrisant (Aug 1893)
- Chelford (Dec 1894)
- St Neots (Nov 1895)
- Snowdon (Apr 1896)
- Menheniot (Feb 1897)
- Welshampton (Jun 1897)
- Penistone (Oct 1897)
- Menheniot (Nov 1897)
- Potters Bar (Mar 1898)
- St Johns (Mar 1898)
- Wellingborough (Sep 1898)
- Wrawby Junction (Oct 1898)
- Potters Bar (May 1899)
![](http://upload.wikimedia.org/wikipedia/commons/thumb/4/45/Arrow_Blue_Right_001.svg/12px-Arrow_Blue_Right_001.svg.png)